Gehl V270 Gen 2, V330 Gen 2 and Mustang 2700V NXT2, 3300V NXT2 Skid Steer Service Repair Manual

Service Repair Manual: 290 Pages
Parts Manual: 290 Pages
Manuals: Service Repair Manual, Parts Manual

Table of Content V270 Gen2 & V330 Gen 2 Manual

Specifications
Specifications
Safety
General Information – Safety
Signal Words
Additional Safety Reminders
Mandatory Safety Shutdown Procedure
Lift Arm Support Device
Lift Arm Support Device Engagement
Lift Arm Support Device Disengagement
ROPS/FOPS – Raising
ROPS/FOPS – Lowering
Relieving Hydraulic Pressure – Dual Joystick, Dual Hand and Hand/Foot Controls – Lift/Tilt/Auxiliary
Relieving Hydraulic Pressure – T-Bar Controls – Lift/Tilt/Auxiliary
Loader Lowering Procedure
Loader Raising Procedure
Lubrication
General Information – Lubrication
Hydraulic Oil Reservoir
Crankcase Oil
Chaincases
Grease Fitting Locations
Cooling System Drain Procedure
Mainframe
Introduction – Mainframe
Mainframe (Chassis) Components
Grille and Engine Cover Components
Engine Access Cover – Removal and Installation
Roll-Over and Falling Object Protective Structure Components – ROPS/FOPS
ROPS/FOPS Removal and Installation
Seat Removal and Installation
Seat Slide Replacement
Side Console Removal and Installation
Non-HVAC Assembly – ROPS/FOPS
HVAC Assembly – ROPS/FOPS
Heater-Only Assembly – ROPS/FOPS
Air Duct Louver Replacement
ROPS/FOPS Rear Window Removal and Installation
Restraint Bar Components
Restraint Bar Removal and Installation
All-Tach® Hitch Components
Actuator Group Components – All-Tach® Hitch
Power-A-Tach® Components
All-Tach® and Power-A-Tach® Hitch Removal and Installation
Lift Arm Components
Lift Arm Removal and Installation
Lift Arm, Rear Link and Timing Link Bushing Replacement
Lift Arm Stop Installation and Adjustment
Control Console Removal and Installation
Clean-Out Cover, Floor Plate and Kickplate Cover Removal and Installation
Crossmember Removal and Installation
Hydraulic Oil Reservoir Removal and Installation
Main Fuel Tank and Auxiliary Fuel Tank Removal and Installation
Fuel Sensor Removal and Installation
Rear Grille Removal and Installation
Rear Grille Latch Removal and Installation
Wheel Drives
Introduction – Wheel Drives
Wheel Drive Components
Drive Chain Adjustment
Axle Housing Assembly Removal and Installation
Axle Assembly Components
Drive Chain Removal and Installation
Axle and Wheel Bearing Disassembly and Assembly
Controls
Introduction – Controls
Control Locations – Dual Joystick, Dual Hand and Hand/Foot Controls
Control Locations – T-Bar Controls
Wheel Drive – Lift/Tilt Components – T-Bar Controls
Wheel Drive – Lift/Tilt Components – Hand/Foot Controls
Wheel Drive – Lift/Tilt Components – Dual Joystick Controls
Wheel Drive – Lift/Tilt Components – Dual Hand Controls
Control Handle Assembly (Both Control Handles) Removal and Installation
Control Handle Removal and Installation – Electrical Auxiliary Grip – Dual Joystick, Dual Hand and Hand/Foot Controls
Control Handle Removal and Installation – T-Bar Controls
T-Bar Control Handle Assembly
Dual Joystick, Dual Hand and Hand/Foot Control Handle Assembly
Pivot Tube Removal and Installation, Disassembly and Assembly – T-Bar Controls
Control Handle Position Adjustment – T-Bar Controls
Control Handle Tracking Adjustment
Neutral Centering Test and Adjustment
Lift/Tilt Control Removal and Installation
Lift/Tilt Control Adjustment – T-Bar Controls
Electrical Foot Throttle Components – Dual Joystick, Dual Hand and T-Bar Controls
Electrical Foot Throttle Removal and Installation – T-Bar, Dual Hand and Dual Joystick Controls
Hydrostatic System
Introduction – Hydrostatic System
Hydrostatic Components – Single-Speed – T-Bar Controls
Hydrostatic Components – Two-Speed – T-Bar Controls
Hydrostatic Components – Single-Speed – Hand/Foot, Dual Hand and Dual Joystick Controls
Hydrostatic Components – Two-Speed – Hand/Foot, Dual Hand and Dual Joystick Controls
Charge Pressure Test and Adjustment
Hydrostatic Pump Relief Valves
Hydrostatic Pump Removal and Installation
Hydrostatic Pump Drive Coupling Removal and Installation
Drive Motor Removal and Installation
Troubleshooting Guide – Hydrostatic System
Hydrostatic/Hydraulic Schematic – Dual Joystick Controls
Hydrostatic/Hydraulic Schematic – Hand/Foot Controls
Hydrostatic/Hydraulic Schematic – T-Bar Controls
Hydrostatic/Hydraulic Schematic – Dual Hand Controls
Hydraulic System
Introduction – Hydraulic System
Troubleshooting Guide – Hydraulic System
Hydraulics – Tank Hydraulic Components
Hydraulics – No Hydraglide Ride Control Components – T-Bar Controls
Hydraulics – Hydraglide Ride Control Components
Hydraulics – Standard Auxiliary Components – Hand/Foot and Dual Joystick Controls
Hydraulics – Standard Auxiliary Components – Dual Hand Controls
Hydraulics – Standard Auxiliary Components – T-Bar Controls
Hydraulics – High-Flow Auxiliary Components – Dual Joystick and Hand/Foot Controls
Hydraulics – High-Flow Auxiliary Components – T-Bar Controls
Hydraulics – High-Flow Auxiliary Components – Dual Hand Controls
Hydraulics – Self-Leveling Components – T-Bar Controls
Hydraulics – Non-Self-Leveling Components – T-Bar Controls
Hydraulics – Self-Leveling Components – Hand/Foot, Dual Hand and Dual Joystick Controls
Hydraulics – Non-Self-Leveling Components – Hand/Foot, Dual Hand and Dual Joystick
Hydraulics – Standard Auxiliary Lift Arm Components
Hydraulics – High-Flow Auxiliary Lift Arm Components
Hydraulics – Power-A-Tach® Components – All Models
Pressure Check, Test and Adjustment
Tilt Cylinder Test
Tilt Circuit Spool Leakage Test
Self-Leveling Valve Test
Lift Cylinder Test
Lift Circuit Spool Leakage Test
Solenoid Valve Test – Lift Arm Pilot Supply, Joystick Drive Supply, Power-A-Tach, Brake/Two-Speed, Safety Locks and Ride Control
Hydraulic Oil Filter Element Replacement
Lift Cylinder Components
Tilt Cylinder Components
Tilt Cylinder Removal and Installation
Lift Cylinder Removal and Installation
Lift/Tilt Cylinder Disassembly / Assembly
Auxiliary Pump Removal and Installation
Self-Leveling Valve (Optional) Removal and Installation
Self-Leveling Valve Adjustment
Brake/Two-Speed, Lift Arm Pilot Supply and Safety Lock Solenoid Valves – Removal and Installation
Lift/Tilt, Joystick Drive Supply, Brake/Two-Speed, All-Tach and Hydraglide™ Ride Control Solenoid Valves – Disassembly and Assembly
Main Control Valve Components – Standard
Main Control Valve Components – High-Flow
Control Valve Removal and Installation
Control Valve Disassembly and Assembly
Control Valve Solenoid Removal and Installation
Inlet Relief Valve, Port Relief Valve and High-Flow Relief Valve Removal and Installation
Hydraglide™ Ride Control Accumulator Removal and Installation
Electrical System
Introduction – Electrical System
Description of Operation – Right and Left Instrument Panels
Troubleshooting Guide – Electrical System
Electrical Chassis Components – DPF Models
Electrical Chassis Components – Non-DPF Models
Electrical Chassis Components – Hydraglide™ Ride Control/Two Speed Components
Electrical ROPS/FOPS Components – DPF Models
Electrical ROPS/FOPS Components – Non-DPF Models
Electrical Engine Components – DPF Models
Electrical Engine Components – Non-DPF Models
Power Distribution Module Test and Operation
Interlock Control Module Test
Interlock Control Module Truth Table – PN 137753 – Earlier Models
Interlock Control Module Truth Table – PN 50305144 – Later Models
Two-Speed, Ride Control and Float Module Test
Two-Speed, Ride Control and Float Module Truth Table
High-Flow Controller Module Test
Standard Auxiliary Flow Controller Module Test
Standard Auxiliary Flow Module Truth Table
Control Handle Actuation Buttons – Two-Speed and Ride Control and Float Module
Electrically-Controlled Standard Auxiliary Hydraulic Flow System Test and Operation
Engine Throttle Test and Operation
Seat Switch Removal and Installation
Electrical Lights Components
Restraint Bar Components
Restraint Bar Switch Removal and Installation
Master Disconnect Switch – Remote Battery Terminal Removal and Installation
Front and Rear Work Light Bulb Replacement
Dome Light Bulb Replacement
Information Center Electronic Display Removal and Installation
Information Center Electronic Display – The Display Modes
DPF (Diesel Particulate Filter) Regeneration (DPF Models)
Regen Terms and Definitions
Stationary Regeneration Safety (DPF Models)
Other Stationary Regeneration Topics (DPF Models)
Stationary Regeneration Procedure (DPF Models)
Stationary Regeneration Abort Procedure (DPF Models)
DPF Regen Flowcharts Introduction (DPF Models)
DPF Regen Flowcharts
Electrical Heater Schematic
Electrical HVAC Schematic
Electrical 14-Pin Auxiliary Schematic
Electrical Engine Schematic (DPF Models)
Electrical Engine Schematic (Non-DPF Models)
Electrical Chassis Schematic (DPF Models)
Electrical Chassis Schematic (Non-DPF Models)
Electrical ROPS/FOPS Schematics
Engine
Introduction, Engine
Troubleshooting Guide, Engine
Engine Components – DPF Models
Engine Components – Non-DPF Models
Air Cleaner and Exhaust Components – DPF Models
Air Cleaner and Exhaust Components – Non-DPF Models
Radiator/Cooler Components
Oil Filter Element Removal and Installation
Air Cleaner Assembly Removal and Installation
Air Filter Element Removal and Installation
Battery and Battery Tray Removal and Installation
Starter Removal and Installation
Exhaust Pipe Removal and Installation – DPF Models
Muffler Removal and Installation – Non-DPF Models
Alternator Belt Adjustment
Radiator/Cooler Removal and Installation
Fan Shroud and Mounting Plates Removal and Installation
Fan Shroud Adjustment
Fan Removal and Installation
Engine Removal and Installation
Engine Diagnostic Fault Codes
Yanmar 4TNV98C-CT/NMS/T4 Engine Diagnostic Fault Codes (DPF Models)
Yanmar 4TNV98T-ZXNMSR / 4TNV98T-ZXNMSF/IT4EUF Engine Diagnostic Fault Codes (Non-DPF Models)
Index