Gehl SL7810E, SL7810E (EU) Skid Steer Loader Service Repair Manual

Service Repair Manual: 238 Pages
Operators Manual: 102 Pages
Parts Manual: 315 Pages
Manuals: Service Repair Manual, Operators Manual, Parts Manual

Table of Content SL7810E, SL7810E (EU) Manual

Specifications
Specifications
Tire Options
Buckets and Capacities
Dimensional Specifications
Safety
General Information
Signal Words
Additional Safety Reminders
Mandatory Safety Shutdown Procedure
Lift Arm Support Device
Lift Arm Support Device Engagement
Lift Arm Support Device Disengagement
Rollover Protective Structure (ROPS) – Raising
Rollover Protective Structure (ROPS) – Lowering
Relieving Hydraulic Pressure
Loader Raising Procedure
Loader Lowering Procedure
Lubrication
General Information
Hydraulic Oil Reservoir
Crankcase Oil
Chaincases
Grease Fitting Locations
Cooling System Drain Procedures
Mainframe
Introduction
Engine Access Covers – Removal and Installation
Rollover Protective Structure (ROPS) Removal and Installation
Seat Removal and Installation
Seat Slide Replacement
Air Duct Removal and Installation
Air Duct Louver Replacement
Rollover Protective Structure (ROPS) Rear Window Removal and Installation
Restraint Bar Removal and Installation
All-Tach™, Power-A-Tach™ Attachment Bracket Removal and Installation
Lift Arm Removal and Installation
Rear Link Removal and Installation
Timing Link Removal and Installation
Links and Lift Arm Bushing Replacement
Control Console Removal and Installation
Floor Cover/Battery Cover Removal and Installation
Crossmember Removal and Installation
Fuel Sensor Removal and Installation
Rear Grille Removal and Installation
Rear Grille Bracket, Latch and Grille Removal and Installation
Rear Bumper Removal and Installation
Wheel Drives
Introduction
Drive Chain Adjustment
Axle Housing Assembly Removal and Installation
Drive Chain Removal and Installation
Axle and Wheel Bearing Disassembly and Assembly
Controls
Introduction
Control Handle Removal and Installation
Control Handle Position Adjustment
Drive Control Handle Tracking Adjustment
T-Bar Control Handle Assembly
Hand/Foot Control Handle Assembly
Dual Hand Control Handle Assembly
Joystick Control Handle Assembly
Pivot Tube Removal and Installation – T-Bar, Hand/Foot and Dual Hand
Neutral Centering Device Adjustment
Control Arm Assembly Removal and Installation
Lift/Tilt Control Removal and Installation
Lift/Tilt Control Adjustment
Auxiliary Hydraulics Cable Removal and Installation – T-Bar and Dual Hand
Auxiliary Hydraulics Cable Adjustment – T-Bar and Dual Hand
Auxiliary Hydraulics Cable Removal and Installation – Hand/Foot
Auxiliary Hydraulics Cable Adjustment – Hand/Foot
Throttle Cable Removal and Installation
Hand Throttle Removal and Installation
Foot Throttle Removal and Installation – T-Bar and Dual Hand
Hand Throttle Tension Adjustment
Hand Throttle Adjustment – Hand/Foot
Foot Throttle Adjustment – T-Bar and Dual Hand
HIGH Idle Adjustment
Hydrostatic System
Introduction
Troubleshooting Guide
Charge Pressure Test and Adjustment
Hydrostatic Pump Relief Valves
Hydrostatic Pump Removal and Installation
Hydrostatic Pump Drive Coupling Removal and Installation
Drive Motor Removal and Installation
Hydraulic System
Introduction
Troubleshooting Guide
Pressure Tests, System and Load-Sense Standby
Tilt Cylinder Test
Self-Leveling Valve Test
Lift Cylinder Test
Solenoid Valve Test – Safety Lock, Brake and Two-Speed
Hydraulic Oil Filter Element Replacement
Tilt Cylinder Removal and Installation
Lift Cylinder Removal and Installation
Lift and Tilt Cylinder Disassembly and Assembly
Load-Sense Axial Piston Pump Removal and Installation
Self-Leveling Valve Removal and Installation
Self-Leveling Valve Adjustment
Safety Lock Valves – Removal and Installation
Lift, Tilt and Safety Lock Valves – Disassembly and Assembly
Control Valve Removal and Installation
Control Valve Disassembly and Assembly
Load-Sense Shuttle Cleaning Procedure
Control Valve Spool Seal Replacement
Anti-Cavitation Relief Valve Removal and Installation
Spool Lock Solenoid Removal and Installation
Hydraulic Tank Removal and Installation
Hydraglide™ Accumulator Removal and Installation
Hydraulic System Schematic, T-Bar, Hand/Foot and Dual Hand Controls
Hydraulic System Schematic, Joystick Controls
Engine
Introduction
Troubleshooting Guide
Oil Filter Element Removal and Installation
Air Cleaner Assembly Removal and Installation
Air Filter Element Removal and Installation
Battery Removal and Installation
Starter Removal and Installation
Exhaust Assembly Removal and Installation
Fan Belt Replacement
Cooler Radiator Removal and Installation
Fan Shroud Removal and Installation
Fan Shroud Adjustment
Engine Removal and Installation
Fuel Tank Removal and Installation
Electrical System
Introduction
Description of Operation – Right and Left Instrument Panels
Troubleshooting Guide
Fuse and Relay Test and Operation
Seat Switch Removal and Installation
Restraint Bar Switch Removal and Installation
Battery Disconnect Switch – Remote Battery Terminal Removal and Installation
Front Work Light Bulb Replacement
Rear Work Light Bulb Replacement
Dome Light Bulb Replacement
Fuse Replacement
Electric ROPS Lift Assist Pump Removal and Installation
Electrical System Schematics
Index