Case DX25, DX29, DX33 Tractor Repair Manual

Manuals: Service Manual

Table of Content (Service Manual)

SECTION 00 – GENERAL INFORMATION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

SECTION 10 – ENGINE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3

SECTION 18 – CLUTCH . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 10

SECTION 21 – GEAR TRANSMISSION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11

SECTION 25 – FWD FRONT AXLE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 14

SECTION 27 – DIFFERENTIAL, REAR AXLE . . . . . . . . . . . . . . . . . . . . . . . . . . . 15

SECTION 29 – HYDROSTATIC TRANSMISSION . . . . . . . . . . . . . . . . . . . . . . . . 16

SECTION 31 – POWER TAKE-OFF SYSTEMS . . . . . . . . . . . . . . . . . . . . . . . . . . 20

SECTION 33 – BRAKES . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 22

SECTION 35 – HYDRAULIC SYSTEM . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 23

SECTION 41 – STEERING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 26

SECTION 44 – WHEELS AND TIRES . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 28

SECTION 55 – ELECTRICAL SYSTEM . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 29

SECTION 90 – PLATFORM . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 37

The following pages are the collation of the contents pages from each section and chapter of the DX29 and DX33 Repair manual. Complete Repair Manual # 87059223.
Manual Extract: Engine Troubleshooting
| PROBLEM
| POSSIBLE CAUSE
| CORRECTION
| Engine does not start
| Faulty starter switch
Insufficient charging or complete discharge of battery
Lack of fuel
Air mixed in fuel system
Clogged fuel filter
Irregular or faulty fuel supply
Glow plug not heating
Improper lubricating oil viscosity
Clogged air cleaner
Faulty engine stop solenoid
Burned out fuse
| Replace switch
Check battery and charging system.
Fill fuel tank
Inspect fuel system for tightness
Replace fuel filter
Replace fuel supply
Replace glow plug
Replace lube oil
Replace air cleaner
Replace solenoid
Replace fuse
| Excessive exhaust smoke
| Air cleaner dirty or restricted
Excessive fuel delivery
| Replace air cleaner
Adjust fuel delivery
| Engine stops while
operating
| Lack of fuel in fuel tank
Clogged fuel filter
Air mixed in fuel system
Faulty engine stop solenoid
Burned out fuse
| Fill fuel tank
Replace filter
Inspect for air leaks
Replace solenoid
Replace fuse