Case 570T Backhoe Loader Repair Manual

Model: Case 570T
Manuals: Service Manual
Introduction
Engine
Four Wheel Drive System
Front Axle
Rear Axle
Hydrostatic Drive
Brakes and Controls
Hydraulic System
Frames and Ballasting
Steering
Wheels
Cab Climate control
Electrical System
Front Loader and Bucket
Booms, dipper and buckets
Platform, Cab, Bodywork and Decals
Special Tool Index
Manual Extract: Front axle – Troubleshooting
| Problem
| Possible Cause
| Correction
| Steering is difficult;
vehicle goes straight
while it’s turning
| Incorrect installation/defective axle
| Correct installation or repair or replace the
differential in case it does not survive any
one of the test phases
| Overloading/incorrect weight distribution
| Remove excessive weight and redistribute
load, following instructions related to the
vehicle
| Different rotation radius of the tires
| If one tire has a smaller radius, it will cause
partial wheel slipping when force is applied.
The other tire with bigger radius will have
to support all the work. Replace the tire
or adjust pressure to have same radius on
both tire
| Broken half shaft
| It is not advisable to operate the vehicle
with a broken half shaft. It is acceptable to
move the vehicle (engine “Off” unloaded) a
few meters away only
| Incorrect use of the product
| See the vehicle producer‘s instructions
once again